AGENCY:
Federal Aviation Administration (FAA), DOT.
ACTION:
Notice of proposed rulemaking (NPRM).
SUMMARY:
We propose to adopt a new airworthiness directive (AD) for the products listed above. This proposed AD results from mandatory continuing airworthiness information (MCAI) issued by an aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI describes the unsafe condition as:
In-flight engine shutdown incidents were reported on aircraft equipped with TAE-125-01 engines. This was found to be mainly the result of operation over a long time period with broken piston cooling oil nozzles which caused thermal overload of the piston.
We are proposing this AD to prevent engine in-flight shutdown, possibly resulting in reduced control of the aircraft.
DATES:
We must receive comments on this proposed AD by October 19, 2009.
ADDRESSES:
You may send comments by any of the following methods:
- Federal eRulemaking Portal: Go to http://www.regulations.gov and follow the instructions for sending your comments electronically.
- Mail: Docket Management Facility, U.S. Department of Transportation, 1200 New Jersey Avenue, SE., West Building Ground Floor, Room W12-140, Washington, DC 20590-0001.
- Hand Delivery: Deliver to Mail address above between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays.
- Fax: (202) 493-2251.
Contact Thielert Aircraft Engines GmbH, Platanenstrasse 14 D-09350, Lichtenstein, Germany, telephone: +49-37204-696-0; fax: +49-37204-696-55; e-mail: info@centurion-engines.com, for the service information identified in this proposed AD.
Examining the AD Docket
You may examine the AD docket on the Internet at http://www.regulations.gov ; or in person at the Docket Operations office between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this proposed AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Operations office (telephone (800) 647-5527) is the same as the Mail address provided in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.
FOR FURTHER INFORMATION CONTACT:
Jason Yang, Aerospace Engineer, Engine Certification Office, FAA, Engine and Propeller Directorate, 12 New England Executive Park, Burlington, MA 01803; e-mail: jason.yang@faa.gov; telephone (781) 238-7747; fax (781) 238-7199.
SUPPLEMENTARY INFORMATION:
Comments Invited
We invite you to send any written relevant data, views, or arguments about this proposed AD. Send your comments to an address listed under the ADDRESSES section. Include “Docket No. FAA-2009-0753; Directorate Identifier 2009-NE-31-AD” at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of this proposed AD. We will consider all comments received by the closing date and may amend this proposed AD based on those comments.
We will post all comments we receive, without change, to http://www.regulations.gov , including any personal information you provide. We will also post a report summarizing each substantive verbal contact with FAA personnel concerning this proposed AD. Using the search function of the Web site, anyone can find and read the comments in any of our dockets, including, if provided, the name of the individual who sent the comment (or signed the comment on behalf of an association, business, labor union, etc.). You may review the DOT's complete Privacy Act Statement in the Federal Register published on April 11, 2000 (65 FR 19477-78).
Discussion
The European Aviation Safety Agency (EASA), which is the Technical Agent for the Member States of the European Community, has issued EASA Airworthiness Directive 2007-0232, dated August 23, 2007 (referred to after this as “the MCAI”), to correct an unsafe condition for the specified products. The MCAI states:
In-flight engine shutdown incidents were reported on aircraft equipped with TAE-125-01 engines. This was found to be mainly the result of operation over a long time period with broken piston cooling oil nozzles which caused thermal overload of the piston.
You may obtain further information by examining the MCAI in the AD docket.
Relevant Service Information
Thielert has issued Service Bulletin No. TM TAE 125-0017, Revision 2, dated February 22, 2008. The actions described in this service information are intended to correct the unsafe condition identified in the MCAI.
FAA's Determination and Requirements of This Proposed AD
This product has been approved by the aviation authority of Germany and is approved for operation in the United States. Pursuant to our bilateral agreement with Germany, EASA has notified us of the unsafe condition described in the MCAI and service information referenced above. We are proposing this AD because we evaluated all information provided by EASA and determined the unsafe condition exists and is likely to exist or develop on other products of the same type design.
Costs of Compliance
Based on the service information, we estimate that this proposed AD would affect about 250 engines of U.S. registry. We also estimate that it would take about 2 work-hours per engine to comply with this proposed AD. The average labor rate is $80 per work-hour. Required parts would cost about $30 per engine. Based on these figures, we estimate the cost of the proposed AD on U.S. operators to be $47,500.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. “Subtitle VII: Aviation Programs,” describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in “Subtitle VII, Part A, Subpart III, Section 44701: General requirements.” Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
Regulatory Findings
We determined that this proposed AD would not have federalism implications under Executive Order 13132. This proposed AD would not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify this proposed regulation:
1. Is not a “significant regulatory action” under Executive Order 12866;
2. Is not a “significant rule” under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and
3. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
We prepared a regulatory evaluation of the estimated costs to comply with this proposed AD and placed it in the AD docket.
List of Subjects in 14 CFR Part 39
- Air transportation
- Aircraft
- Aviation safety
- Incorporation by reference
- Safety
The Proposed Amendment
Accordingly, under the authority delegated to me by the Administrator, the FAA proposes to amend 14 CFR part 39 as follows:
PART 39—AIRWORTHINESS DIRECTIVES
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
2. The FAA amends § 39.13 by adding the following new AD:
Thielert Aircraft Engines GmbH: Docket No. FAA-2009-0753; Directorate Identifier 2009-NE-31-AD.
Comments Due Date
(a) We must receive comments by October 19, 2009.
Affected Airworthiness Directives (ADs)
(b) None.
Applicability
(c) This AD applies to Thielert Aircraft Engines GmbH (TAE) model TAE 125-01 reciprocating engines, excluding engines that have been modified to TAE Design Modification No. 2007-001. These engines are installed in, but not limited to, Diamond Aircraft Industries Model DA42, Piper PA-28-61 (Supplemental Type Certificate (STC) No. SA03303AT), Cessna 172F, 172G, 172H, 172I, 172K, 172L, 172M, 172N, 172P, 172R, 172S, F172F, F172G, F172H, F172K, F172L, F172M, F172N, and F172P (STC No. SA01303WI) airplanes.
Reason
(d) This AD results from mandatory continuing airworthiness information (MCAI) issued by an aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI describes the unsafe condition as:
In-flight engine shutdown incidents were reported on aircraft equipped with TAE-125-01 engines. This was found to be mainly the result of operation over a long time period with broken piston cooling oil nozzles which caused thermal overload of the piston.
We are issuing this AD to prevent engine in-flight shutdown, possibly resulting in reduced control of the aircraft.
Actions and Compliance
(e) Unless already done, do the following actions:
(1) Within the next 110 flight hours, or during the next scheduled maintenance, whichever occurs first after the effective date of this AD, inspect the engine and engine oil for any evidence or pieces of broken piston cooling nozzles.
(2) Use the inspection instructions in Thielert Service Bulletin No. TM TAE 125-0017, Revision 2, dated February 22, 2008, to perform the inspection.
(3) Thereafter, repetitively inspect the engine and engine oil for any evidence or pieces of broken piston cooling nozzles, within every additional 100 flight hours.
(4) If any evidence of a failed cooling nozzle is found, remove the engine from service before further flight.
Alternative Methods of Compliance (AMOCs)
(f) The Manager, Engine Certification Office, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19.
Related Information
(g) Refer to European Aviation Safety Agency AD 2008-0016 R1, dated February 22, 2008, and Thielert Aircraft Engines GmbH, Platanenstrasse 14 D-09350, Lichtenstein, Germany, telephone: +49-37204-696-0; fax: +49-37204-696-55; e-mail: info@centurion-engines.com, for related information.
(h) Contact Jason Yang, Aerospace Engineer, Engine Certification Office, FAA, Engine and Propeller Directorate, 12 New England Executive Park, Burlington, MA 01803; e-mail: jason.yang@faa.gov; telephone (781) 238-7747; fax (781) 238-7199, for more information about this AD.
Issued in Burlington, Massachusetts, on September 10, 2009.
Peter A. White,
Assistant Manager, Engine and Propeller Directorate, Aircraft Certification Service.
[FR Doc. E9-22314 Filed 9-16-09; 8:45 am]
BILLING CODE 4910-13-P